Summer Rerun — Book Review: Life in a Soviet Factory

Bitter Waters: Life And Work In Stalin’s Russia by Gennady Andreev-Khomiakov

A fascinating look at the Soviet economic system in the 1930s, as viewed from the front lines of that system.

Gennady Andreev-Khomiakov was released from a labor camp in 1935, and was fortunate to find a job as a book-keeper in a sawmill. When the factory manager, Grigory Neposedov (a pseudonym) was assigned to run a larger and more modern factory (also a sawmill), he took Gennady with him.

Although he had almost no formal education, Neposedov was an excellent plant manager. As Gennady describes him:

He was unable to move quietly. Skinny and short, he moved around the plant so quickly that he seemed to be running, not walking. Keeping pace with the director, the fat chief mechanic would be steeped in perspiration…He rarely sat in his office, and if he needed to sign some paper or other, you had to look for him in the mechanic’s office, in the shops, or in the basement under the shops, where the transmission belts and motors that powered the work stations were located…This enthusiasm of his, this ability to lose himself completely in a genuine creative exertion, to give his all selflessly, was contagious. It was impossible to be around Neposedov without being infected by his energy; he roused everyone, set them on fire. And if he did not succeed in shaking someone up, it could unmistakely be said that such a person was dead or a complete blob.

With his enthusiasm and dedication to his factory, Neposedov comes across almost as a Soviet version of Hank Reardon (the steel mill owner in Ayn Rand’s Atlas Shrugged), with this difference–Nepodesov could throw himself as enthusiastically into bureaucratic manipulation as into his technical and leadership work. All of his skills would be needed to make this factory a success.

Although the sawmill had modern equipment, it was producing at only a fraction of its design capacity. One of the problems was energy: the plant was powered by a 200HP steam engine, and whoever had built the place had spent almost all of the budget on other equipment, leaving very little for the boiler. The original boiler that came with the plant turned out to be useless, and was replaced with a salvaged boiler..this worked, but was not in good shape and produced only about half the steam needed to run the engine–and the plant–at full power.

At this point in history, and in this particular corner of the Soviet economy, the amount that was available to be paid to workers was strongly related to the output of a plant. And workers at this sawmill were becoming increasingly desperate, on the point of actual starvation. Neposedov, aided by Gennady, pusued a three-part program of improvement: (1)fix the boiler, (2)improve the workflow (as we would now call it) within the plant, and (3)put in place an incentive system for the workers.

New “pipes” for the boiler were somehow obtained (I think “pipes” in this context refers to boiler flues) and the workflow was continuously analyzed and improved. The most interesting part of the story, though, deals with the incentive program. The plant manager apparently had discretion to put such programs in place as long as he could pay for them out of increased output. (As the book describes it, there were extensive accounting systems in place throughout the Soviet economy–indeed, Lenin had once gone so far as to say “Socialism is accounting.” The accounting seems a bit similar to what you would find in a multidivisional American company with extensive intracompany transactions.) The incentive system that Gennady designed for this sawmill was based on very sharp pay increases for the workers when production exceeded target–so that, for example, you could double your pay by producing only 25% over target. (Actually, the plan paid collectively by group and by shift, rather than on an individual basis.)

The incentive plan, together with the repaired steam boiler, resulted in very high production–140%, then 160% of target–and correspondingly high pay for the workers. Gennady had some nervous moments when he feared he had made a mistake in the calculations and the cost of the additional wages would exceed the amount generated by the new production….a mistake like this could easily have landed him back in Siberia, or worse. But it turned out that the new system was indeed sustainable.

The local Communist Party leadership, while pleased with the increased production, was disturbed that the propaganda buzzwords of the day were not being implemented. “Socialist competition” was hot at the time, and the Party organizer insisted on competition at the individual worker levels, not just the group and shift level.


With a look of incomprehension, I asked the Party organizer: “Why draw up individual agreements, if the whole shift is working to fulfill a single, common norm? Is there any sense in that?”

The Party organizer did not understand: “What do you mean, sense? Let them work more zealously at their own jobs, not hold back the others.”

“They already have no interest in holding back the others. Everyone knows that would only mean depriving themselves of earnings.”

“That’s beside the point!” exclaimed the Party organizer in vexation. “They now hurry subconsciously, but give them a socialist obligation and they will know exacty what’s what. We have the complete picture.”

I smiled to myself, thinking, It isn’t the picture you’re after. What drives you is the need, according to the prescribed Party order, to beat down the impulses of people, to saddle them and make them your dependents by creating the impression that their success is due to “socialist methods of labor.”

High-level Party officials visited, wanting to know the reasons for the factory’s success. They were not satisfied with the simple truth–“we repaired the boiler, put the equipment in order, gave the workers a chance to earn a bit more”–but wanted to recast the success in terms of the catch-phrases of the time–“socialist methods,” or “shock work tactics and competition.” The Party was particularly disturbed that there could be a factory hitting almost 200% of target without any identified Stakhanovites (heroic workers of extraordinary productivity–named after Alexis Stakhanov, a coal miner who once produced 102 tons in a single shift.) Neposedov was told that he’d better find some Stakhanovites and publicize their achievements. This was problematic since the production records were only at the group/shift level. but four workers were duly selected and stories about them were run in the district newspaper–even though there was nothing particularly exceptional about their performance.

What great irony! The Communist leadership demands a more individually-based incentive system, and the plant manager–who would probably have been very much at home running a Western, capitalist plant…reluctantly complies.

The most difficult problems faced by this factory involved the acquistion of supplies. Equipment and spare parts were always difficult to get, becaue of the rigidity of the planning process, and personal relationships were key, along with off-the-books trading and outright bribery. The plant was entirely dependent on the supply of raw lumber, and allocation decisions were arbitrary and very political. Gennady, whose father had been in the lumber trade before the revolution, was contemptuous of the chaos into which the industry had been reduced by the Soviets:

The free and “unplanned” and therefore ostensibly chaotic character of lumber production before the revolution in reality possessed a definite order. As the season approached, hundreds of thousands of forest workers gathered in small artels of loggers, rafters, and floaters, hired themselves out to entrepreneurs through their foremen, and got all the work done. The Bolsheviks, concerned with “putting order” into life and organizing it according to their single scheme, destroyed that order and introduced their own–and arrived at complete chaos in lumbering.

As Gennady says:

Such in the immutable law. The forceful subordination of life’s variety into a single mold will be avenged by that variety’s becoming nothing but chaos and disorder.

The factory was gradually strangled by supply problems. Neposedov responded by getting approval to conduct his own lumbering operations, sending white-collar as well as blue-collar workers into the forests to cut down trees, but was unable to get either power equipment or sufficient horses to conduct this operation effectively. A trickle of lumber still flowed into the mill, but not enough to run at more than a small fraction of capacity. All of Neposedov’s creativity, cunning, and drive could not save the situation. Gennady, with Neposedov’s permission, left to take a new job in Moscow with a planning organization.

While at the sawmill, Gennady had had little involvement in politics:

The events of the Yezhovhchina and the Moscow trials found almost no echo in our plant. We attended meeting where propagandists from the district Party committee spoke about the “search for enemies of the people.” Acording to the prescribed order, we dutifully voted for the death sentence, but we almost never discussed such things among ourselves. The violence was occurring far away somewhere, at some inaccessible height, and people sensed that it was better not to talk about such things.

In Moscow, he became involved with a group of friends who were critical of the regime, but had little in the way of specific ideas about what should be done:

Although many similar thoughts and desires “were floating in the air,” without a free exchange of opinions it was impossible to gather them together and reduce them to a system that could be put into effect. Apart from our dissatisfaction, criticism, and negation, we had no ideas that could become a driving force with which to oppose the authorities.

Gennady and his friends were especially confused by visitors from the West who spoke in glowing terms of the Soviet Union’s accomplishments:

Romain Rolland, Lion Feuchtwanger, the two Webbs, and many others frequently made enthusiastic comments about what they saw. We were puzzled as to what evoked such raptures. Was this captivation the result of an inexplicable blindness, or was there actually something bad in the West that was unknown to us, an evil that eclipsed even our own ugliness?

When the Germans attacked in 1941, there was some hope that the fall of the regime might result in something better–but Nazi barbarity very quickly put an end to that notion. As the enemy forces near Moscow, whole factories were dismantled and moved east. Hundreds of thosands of people, with and without order, fled the city. Women from Gennady’s workplace were among those sent to dig trenches:

They took us just outside Rzhev, to a forest where there were no barracks or houses. You make yourself comfortable on the ground, under the firs! The authorities put up a tent for themselves, but we were under the sky…Rain poured through the branches; we were all wet–what a nightmare! They gave us shovels, sent us into a field, told us to dig! And we were in pumps and sheer stockings. Where I work I wear dress shoes. If I wear only dress shoes to work, why would I have a pair of everyday shoes? And if all I know is how to cook a meal and pound on a typewriter, how am I supposed to suddenly dig trenches? Well, we dug..The food situation was desperate, they gave us slop. We lived on bread. Imagine two thousand women from Moscow, in the rain, becoming so raggedy, sickly, and tormented that they cannot even be recognized. A real menagerie!

Eventually, Gennady decided to join the exodus to the east:

The train moved slowly, as if threading its way with difficulty through the darkness. Switch signal lights again swam pat–on to Tovarnoy and Kkruzhony Stations, then again pitch-blackness. We suddenly stopped and stood still for a long while. It seemed that the entire train, even the cars and the steam engine, were listening, surely in alarm, extending a slim, smokestack ear to the sky…”Don’t be sad, old man,” remarked Vasyukov quietly, without his usual bantering tone. “Tears. as they say, won’t help. Ah, Moscow, yes what shall we do for Moscow?…Let us drink to her health, may she have better days ahead.”<

Gennady enlisted in the army in 1942 and was captured by the Germans in the Crimea. He spent the remainded of the war as a prisoner, remaining in Germany after the war and eventually moving to the United States.

A fascinating and well-written book, especially recommended for those who are interested in the history of Russia, Communism, and industrial organization.

4 thoughts on “Summer Rerun — Book Review: Life in a Soviet Factory”

  1. I read it several years ago, most likely on your recommendation.
    IIRC, one point the book made was that in order to produce to quota- or near to quota- laws had to be broken.I believe there were a lot of not quite kosher maneuvers between suppliers.

  2. Gringo…in another book about the Soviet Union, “Red Plenty” (review coming), one of the characters is a man who was a salesman before the Revolution and is now a fixer, helping state enterprises get what they need to operate. He observes that under capitalism, the hard part is getting people to *buy* what you produce, under socialism, the hard part is getting people to *provide* what you require.

  3. I still remember doing a spit take when some media type back in the 90’s marveled how quickly corruption became established after the fall of the Soviet Union. Either too stupid or credulous to realize the corruption was there from the beginning, the party just institutionalized and systematized it.

    China is supposed to be grappling with the problem. The most quickest way into a jail cell is to catch the wrong crook or inquire too closely into who he was paying off.

    An FBI that was less interested in determining elections could start paying attention to how any number of congress critters have become wealthy.

Comments are closed.